Hitachi ZW140, ZW150 Wheel Loader Service Manual

Hitachi ZW140, ZW150 Wheel Loader Service Manual

$33.00

Wheel Loader ZW140, ZW150 Workshop Manual : Vol. No.W4FC-E-00 (454 Pages)

Categories: ,
  • Description
  • Table of Content
  • Reviews (0)

Description

Hitachi ZW140, ZW150 Wheel Loader Service Manual

The manual is applicable for the Hitachi ZW140, ZW150 Wheel Loader Model

Format: PDF
Language: English
Service Manual consists of the following:

For Model ZW140, ZW150 as mentioned above:

Workshop Manual : Vol. No.W4FC-E-00 (454 Pages)

Table of Content of the Workshop Manual

SECTION 1 GENERAL
Group 1 Precautions for disassembling
and Assembling
Group 2 Tightening
Group 3 Painting
Group 4 Bleeding Air from Hydraulic Oil
Tank
SECTION 2 BODY
Group 1 Cab
Group 2 Counterweight
Group 3 Center Hinge
Group 4 Hydraulic Oil Tank
Group 5 4-Unit Gear Pump
Group 6 Control Valve
Group 7 Pilot Valve
Group 8 Pilot Shut-Off Valve
Group 9 Fan Pump
Group 10 Fan Motor
SECTION 3 TRAVEL SYSTEM
Group 1 Tire
Group 2 HST Pump
Group 3 HST Motor
Group 4 Transmission
Group 5 Axle
Group 6 Propeller Shaft
Group 7 Brake Valve
Group 8 Charging Block
Group 9 Steering Valve
Group 10 Steering Cylinder
Group 11 Priority Valve
SECTION 4 FRONT ATTACHMENT
Group 1 Front Attachment
Group 2 Cylinder

Manual guide composition

Hitachi ZAXIS ZW140, ZW150 service manual consists of the Troubleshooting and the Workshop Manual.

  • Information included in the Service Manual: Technical information needed for redelivery and delivery, operation and activation of all devices and systems, operational performance tests, and troubleshooting procedures.
  • Information included in the Workshop Manual: Technical information needed for maintenance and repair of the machine, tools and devices needed for maintenance and repair, maintenance standards, and removal / installation and assemble / disassemble procedures.

Periodic Replacement Parts
In order to ensure safe operation, conduct periodic inspection of the machine.In order to ensure safe operation further, conduct periodic replacement of the parts below specially related to safety.
Theses parts deteriorate, fatigue and weaken with time.
This may cause serious personal/impersonal hazard.
As it is very difficult to gauge remnant life of these parts according to driving sensation or appearance inspection , replace them with the new ones regardless of defect in the interval.
If any of these parts are found to be defective according to periodic inspection

Hydraulic System Pump Suction hose and Delivery hose replace every 2 years

 

  • Workshop Manual
  • SECTION 1 GENERAL INFORMATION
    Group 1 Precautions for disassembling and
    Assembling
    Group 2 Tightening Torque
    Group 3 Painting
    Group 4 Bleeding Air from Hydraulic Oil Tank
    SECTION 2 UPPERSTRUCTURE
    Group 1 Cab
    Group 2 Counterweight
    Group 3 Main Frame
    Group 4 Pump Device
    Group 5 Control Valve
    Group 6 Swing Device
    Group 7 Pilot Valve
    Group 8 Pilot Shut-Off Valve
    Group 9 Signal Control Valve
    Group 10 Travel Shockless Valve
    Group 11 Solenoid Valve
    Group 12 Pilot Relief Valve
    Group 13 Steering Valve
    Group 14 Brake Valve
    Group 15 Accumulator Charging Valve
    Group 16 Transmission Control Valve
    SECTION 3 UNDERCARRIAGE
    Group 1 Swing Bearing
    Group 2 Travel Motor
    Group 3 Center Joint
    Group 4 Transmission
    Group 5 Axle
    Group 6 Axle Lock Cylinder
    Group 7 Operate-Check Valve
    Group 8 Propeller Shaft
    SECTION 4 FRONT ATTACHMENT
    Group 1 Front Attachment
    Group 2 Cylinder
    Group 3 Hose-Rupture Safety Valve
    Group 4 Operate-Check Valve
    SECTION 5 ENGINE

    Service Manual (Troubleshooting)
    SECTION 4 OPERATIONAL PERFORMANCE
    TEST
    Group 1 Introduction
    Group 2 Standard
    Group 3 Engine Test
    Group 4 Excavator Test
    Group 5 Component Test
    Group 6 Adjustment
    SECTION 5 TROUBLESHOOTING
    Group 1 General
    Group 2 Component Layout
    Group 3 Troubleshooting A
    Group 4 Troubleshooting B
    Group 5 Troubleshooting C
    Group 6 Electrical System Inspection
    Group 7 ICX

Reviews

There are no reviews yet.


Be the first to review “Hitachi ZW140, ZW150 Wheel Loader Service Manual”

You've just added this product to the cart: